NYC01LA077

During engine start, while being pushed back, both engines went to a high power setting. The airplane pushed forward against the tow bar, sheared a pin, bent the tow bar, and struck the tug. Before engine start, maintenance personnel had conducted an automated check which included automatic movements of the control wheel and throttles. The flight crew returned to their seats while the test was being conducted. At the completion of the test, the airplane was returned to service and maintenance personnel departed the cockpit. The captain initiated the BEFORE STARTING ENGINES checklist without either pilot first completing a cockpit flow setup as required by company procedures. The checklist was then interrupted by a cockpit visitor and a non-pertinent conversation took place for 3 1/2 minutes. When the checklist was resumed, several items had been missed. As the checklist was continued, the call out THRUST LEVERS was made by the first officer, and the correct response of CLOSED was given by the captain. Push back was initiated, and the captain verbalized starting the first engine as required by the checklist. As the first engine was being started, the captain initiated another non-pertinent conversation with the first officer. The second engine was then started without verbalization as required by company checklist procedures. Although company checklist procedures made both pilots responsible for ensuring a normal start, neither pilot detected that the engines were accelerating above normal idle. According to follow-up testing, the engines accelerated to a power setting that corresponded to the last position of the throttles at the completion of the automated test by maintenance.

On February 6, 2001, about 1200 eastern standard time, a Fokker F28 Mk 0100, N1457B, operated by American Airlines as flight 1813, was substantially damaged during engine start and pushback, at Logan International Airport, Boston, Massachusetts. The 2 certificated airline transport pilots, 2 flight attendants, and 26 passengers were not injured. An instrument flight rules (IFR) flight plan had been filed, but not activated for the scheduled passenger flight. Visual meteorological conditions prevailed for the flight that was operated under 14 CFR Part 121.

The flight crew flew the airplane from Washington, DC, to Boston. They reported that during the approach into Boston, they experienced auto-throttle, auto-pilot, and stabilizer trim faults. The discrepancies were written up and maintenance was notified. After arrival at the gate, the captain went inside to prepare for the return flight to Washington. The first officer conducted a walk around inspection.

To clear the discrepancies prior to the next flight, maintenance personnel initiated a, "40 Full System Check." The check was conducted from a test panel located in the cockpit, and included multiple automatic movements of the control wheel and throttles. While the test was in progress, the pilots returned to the cockpit and sat in their seats. At the completion of the 40 Full System Check, maintenance personnel cleared the discrepancies and returned the airplane to service.

According to a transcript of the cockpit voice recorder, following the departure of the maintenance personnel, and with both pilots in their seats, the captain initiated the Before Starting Engines checklist at 1151:43.

At 1151:58, the first officer called, "fuel panel" however, the captain did not respond to the challenge and instead stated, "let's un, before I forget, lets update…" Four seconds later, the gate agent came to the cockpit and asked if everything was fixed. A discussion with the gate agent ensued.

At 1152:55, the captain said, "all right, now, where were we?", and the first officer replied, "okay, we're at I-R-S's" (Inertial Reference System). This was the item prior to the fuel panel. Both pilots then started to address their FMS (Flight Management System) setup.

At 1153:16, the company's Boston chief pilot arrived at the cockpit door, and the captain introduced himself.

From 1153:16 through 1156:44, the chief pilot, captain, and first officer engaged in a conversation not related to the checklist. The chief pilot departed at 1156:44, after which, the flight crew entered into a discussion about the FMS. During this time, there were also momentary conversations with the gate agent.

At 1157:54, the tug driver established contact with the cockpit by interphone.

At 1158:01, the captain called, "brakes released", and asked for the checklist.

The checklist was resumed at 1158:05, with first officer stating, "where were we, rudder pedals and seats, FMS?", to which the captain replied, "checked." The fuel panel, which had previously been called by the first officer, was not answered by the captain. In addition, the following items, listed below were also not recorded on the CVR as either being called or responded to:

Pressurization

Probe and Window Heat

Emergency Lights

FMP [Flight Mode Panel]

EFIS [Electronic Flight Information System]

Altimeters

Gear Selector/Lights

At 1158:09, the first officer called, "thrust levers", and the captain replied, "closed."

From 1158:14 through 1158:52, the captain and first officer engaged in a discussion about the FMS again. The checklist resumed at 1158:53.

At 1159:44, the first officer radioed Boston Clearance Delivery for pushback and it was approved.

As the pushback was initiated, there was a further discussion between the captain and first officer about the FMS setup.

Prior to engine start, the Before Starting Engines, Five Minutes Prior To Departure, and Prior to Engine Start Or Push-Out checklists had been completed, except for the previously mentioned exclusions.

At 1201:57, the captain stated, "cleared to start.", followed by, "all right, number one." The CAM (cockpit area microphone) recorded several clicks similar to start switch activation.

At 1202:10, the captain initiated a conversation not related to engine starting with the first officer.

The second engine was started without verbal comment, while the conversation between the captain and first officer continued.

At 1202.56, the captain stated, "kay, engine anti-ice on."

At 1203:00, the CAM recorded the sound of several irregular bumps.

At 1203:01, the captain stated, "whoa".

At 1203:02, the CAM recorded numerous sounds of impact lasting for four seconds.

At 1203:06, the captain stated, "we're done."

The engines were shutdown, and stairs were brought to the airplane for the passengers to deplane.

In a follow-up telephone interview, the captain reported that he elected to start both engines while being pushed back, and anticipated a 90-degree turn. The left engine was started first, followed by the right engine. The captain reported that he saw the tug moving to the left of the airplane's nose and assumed the airplane was still under control of the tug driver. He then felt a "ratcheting motion", after which, the airplane stopped. He then shut down both engines. The captain reported his feet were off the rudder pedals during the pushback, and he did not apply brakes until after the airplane had stopped.

The captain also reported that after the occurrence, a ground support person climbed up on the tug and told him that the airplane had struck the pushback tug, and that both engines had been at high power. The captain reported that he thought the throttles were at idle and then touched them, and was surprised that they moved to the idle position. He did not remember the amount of movement.

The captain further reported that he normally checked that the throttles were closed three different times prior to engine start. The first time would be as he entered the cockpit seat, the second time would be during the cockpit flow, prior to reading the checklist, and the third time would be during the checklist. He added that he could not do the first two items because the 40 Full System Check was taking place when he entered the cockpit and took his seat.

The first officer reported that she remembered seeing the throttle positions matched as the number one engine accelerated, and then she diverted her attention to the number two engine gauges as it was being started.

Both pilots reported that they were dividing their time between inside cockpit scans and outside due to the tight maneuvering space. In addition, both pilots believed that the engine starts were normal, and that the throttles had been closed during start.

The flight crew also reported that they were on the third day of a three-day sequence. They had never flown together before this sequence. They had gone on duty at 0830, and been off duty since 1838 on the preceding day. They had made one previous flight during the day, on the date of the accident.

According to the preface on the checklist:

"The items on the Before Starting Engines checklist will have previously been or will be accomplished by the appropriate crewmember(s) as indicated by the duty assignment column."

"This checklist is accomplished by challenge and response. The First Officer will read the challenge portion. The Captain will respond aloud to all items ensuring accomplishment of all checks and items…."

Under duty assignments, the captain was responsible for ensuring the thrust levers were closed prior to initiating the checklist.

On the Starting Engines Procedures, the captain was expected to verbalize, "Ready to start No 1(2) engine."

Under the duty assignments during engine start, the following res