Service difficulty report · Pulley · Raythn HAWKER800XP

Difficulty date
May 6, 2009
Submitted
May 6, 2009
Operation
Air carrier
Aircraft
N883QS
Make and model
Raythn HAWKER800XP
Aircraft serial
258773
Aircraft time
1,998 hours, 1,431 cycles
Part
Pulley
Condition
Obstructed
Location
Elevator Control
Stage of operation
TO
How discovered
O
Nature of condition
C, F
Precautionary procedure
C

As reported to the FAA. Reports are unverified, and codes are left as the FAA publishes them.

What was found

ON TAKE OFF, PULLED BACK AND FOUND YOKE WOULD ONLY MOVE ABOUT 4 INCHES AFT FROM FULL FORWARD. TAKEOFF WAS ABORTED AT ABOUT 100 KIAS , CONTROL CHECK WAS NORMAL WITH AFTER START CHECKLIST. INSPECTED ELEVATOR CONTROL SYSTEM AND FOUND A SMALL SCREW LAYING IN A PULLY GROOVE FOR THE ELEVATOR TRIM ACTUATOR. REMOVED SCREW AND ELEVATOR OPS CHECKS GOOD IAW MM 27-30-00.