SDR REXA2015091700870

Service difficulty report · Clamp · Cndair CL6002D24

Difficulty date: September 17, 2015
Submitted: September 21, 2015
Operation: Air carrier
Aircraft: N914XJ
Make and model: Cndair CL6002D24
Aircraft serial: 15149
Aircraft time: 19,397 hours, 12,417 cycles
System (JASC): 3610 · Pneumatic Distribution System
Part: Clamp
Condition: Defective
Location: Bleed Air Sys
Stage of operation: CL
How discovered: O
Nature of condition: J
Precautionary procedure: A

As reported to the FAA. Reports are unverified, and codes are left as the FAA publishes them.

What was found

RIGHT BLEED DUCT MASTER WARNING AT 5000 FT. REACTIVATED RT ENG PRSOV IAW AMM 36-12-01-440-80. PERFORMED ENG RUN UP IAW FIM 36-19-01 FOR TROUBLESHOOTING, NO DEFECTS NOTED AT THIS TIME. WHILE TROUBLESHOOTING, FOUND BLEED AIR LEAK AT RT PRE-COOLER TEE DUCT V BAND CLAMP. REMOVED AND REPLACED WITH SERVICEABLE UNITS. CLAMP OPENING REDIRECTED AWAY FROM DETECTION LOOP IAW AMM 361911. OPS CHECKED GOOD, NO LEAKS FOUND. R & R PACK ACM IAW AMM 215108400801. OPS CHECKED & LEAK CHECKED GOOD. REFER TO AML 31905192.