Service difficulty reports · 13
Matched to this aircraft by N-number and event date, checked against the reported serial number, make and model.
SDR ERAA094443Mast · making metalTRANSMISSION MAKING METAL ACTION TAKEN: DISASSEMBLED, CLEANED AND VISUALLY INSPECTED ALL PARTS AND BEARINGS FOR METAL CONTAMINATION. INSPECTED AND REASSEMBLED IAW 412 CR AND O CHAPTER 63, T.B. 412-96-137 AND T.B. 412-98-150 INSTALLING NEW MAST POLE, NEW BEARSDR ERAA091810Blade · damagedUNABLE TO TRACK, DIVES OVER 40 KNOTS WITH ANY ADJUSTMENT. SENT FOR REPAIR. INSPECTED, PERFORMED 2500 HOUR INSPECTIONS IAW BHT-412-MM CHAPTER 5: XRAY INSPECTION OF TRAILING EDGE CORE IN AREA OF OB TRIM TAB REVEALS APPROX 50-75 CELLS OF MOISTURE INGRESSION IAW SDR ERAA085161Bearing · roughTRUNNION FEELS ROUGH, PITCH HORN BUSHINGS & INBOARD BOLTS, NUTS & WASHERS MISSING. REMOVED TRUNNION, HOUSINGS, SCRAPPED TRUNNION & TRUNNION BEARINGS. INSTALLED NEW TRUNNION, BEARINGS & SEALS. REASSEMBLED, TORQUED, SAFTIED, MARVEL BALANCED IAW 412 CR&O &TB 41SDR ERAA082944Blade · damagedBLADE TIP VOIDED. INSPECTED, REPLACED TIP CLOSURE. REPLACE BUFFER PADS 2 EA ON LOWER SURFACE.SDR ERAA082700Spindle · splitSPINDLE BEARING STARTING TO SPLIT, DELAMINATING. SPINDLE SCRAPPED. PITCH HORN, NUT, WASHER AND PINS (8EA) VISUALLY INSPECTED AND FOUND TO BE IN SERVICEABLE CONDITION IAW BHT-412-CR&O. ALL PARTS RTS'D.SDR ERAA080468Indicator · contaminatedUNIT DROPS OFF LINE, SLOW TO COME ON. WATER DAMAGE, BAD LOW VOLTAGE, VIDEO SWEEP; DATA PROCESSING ON CONTROL LOGIC CARTS. ACTION TAKEN: REMOVED CORROSION, REPLACED BAD COMPONENTS ON ALL BAD CARDS, ALIGNED AND TESTED.SDR ERAA078458Blade · damagedINSPECTION DUE TOP SKIN 1/3 DOWN LENGTH OF BLADE FROM ROOT, VOIDED AREA AS MARKED, EDGES OF INBOARD TAB POPPED UP. ESTANE BOOT DAMAGED, LOWER SURFACE GRIP VOID, INBOARD TRIM TAB VOID WITH GLASS DAMAGE, INBOARD ABRASION STRIP TANG VOID UPPER AND LOWER SURFACESDR ERAA076679Damper · crackedDAMPER SET IS WEAK/ WORN / CRACKED. ACTION TAKEN: DAMPER SET WAS RETIRED & SCRAPPED IAW 412 CR&O. THIS INFORMATION FOR FAA SDR.SDR ERAA076678Damper · crackedDAMPER SET IS CRACKED. FOUND SETS WORN & CRACKED ACTION TAKEN: RETIRED & SCRAPPED IAW 412 CR&O, THIS INFORMATION FOR FAA SDR.SDR ERAA073271Screw · strippedSCREW IS STRIPPED. SCREWS STRIPPED OR BACKING OUT OF VALVE BODY. NOTE: SCREWS WERE LOCK WIRED. TSDR ERAA061005Transceiver · misoverhauledTRANSCEIVER UNIT REPAIRED 10-1-98 AND INSTALLED ON AIRCRAFT. UNIT FAILS TO PULL FLAGS.SDR ERAA059978Transceiver · malfunctionedTRANSCEIVER UNIT HAS 24 FLIGHT HOURS SINCE REPAIR. NEEDLE GOES TO HIGH SIDE OF GAUGE AND NEVER COMES DOWN.SDR ERAA059976Transceiver · failedTRANSCEIVER UNIT INTERMITTENT AND WILL NOT TEST.